Shaffer v. Haish , 110 Pa. 575 ( 1885 )

Mr. Justice Paxson

delivered the opinion of the court, November 2d, 1885.

The defendants are manufacturers of barbed steel wire. Their works are located at Johnstown, in this state, and the plaintiff was in their employ. While so engaged he was seriously and permanently injured by a machine he was operating, and this action was brought against his employers, to recover damages for such injury. The ground upon which he seeks to recover is that they were negligent in this, that they did not furnish him with a safe machine. The learned judge below was of opinion that the charge of negligence had not been made out, and gave the jury a binding instruction to find for the defendants. This is the principal matter of complaint.

It was the duty of the defendants to furnish those in their employ with ordinary machinery, such as with reasonable care may be used with safety. This was the precise measure of their duty ; nothing more ; nothing less. They are not bound to insure against accidents. So long as leather will stretch and iron will break, accidents will occur. Nor are they to be held liable where an employee is injured in whole or in part as the result of his own negligence.

These principles, thus briefly stated, cover this case. It remains but to apply them to the facts as they were developed upon the trial below.

The plaintiff at the time of the injury was operating one of the machines, all of which were alike so far as the testimony shows. It was run by a cross-belt as were several of the others. When it was needed to stop the machine a lever was used to throw the belt off the driving pulley to a loose pulley. When once so thrown off and the lever held until the belt had properly adjusted itself overhead to the pulley which supplied the power, the machine could not start until the belt was thrown back again upon the driving pulley. Upon the occasion referred. to the plaintiff had stopped his machine and whilé engaged in removing the spool of wire the machine started and he was caught in the cogs and injured as before described.

Was the machine defective in its original construction, or had it become so by reason of use or other cause ?

There was certainly no evidence as to the first proposition. It was claimed, however, that the machine was defectivo and unsafe at the time the injury occurred. The learned counsel for the plaintiff have collected in their printed argument upon page 19 of their paper book, the testimony upon which they rely and which they urge should have been submitted to the jury. I quote from the paper book:

“ Thomas Reese (page 10) says the machine did not seem to work properly. On cross examination (page 12) he says: I thought it run a little too fast, and I did not like to work on that machine the way it run.” The witness upon his cross examination further said, in reply to the question “Well, what was the matter with the machine? Well, what was wrong with it when I was there as far as my knowledge runs was she did not work right; didn’t barb right; didn’t give satisfaction.” The witness also said the defect he referred to had nothing to do with the stopping or starting of the machine. It was not even alleged that the failure of the machine to barb the wire properly, had any connection with the accident. This testimony does not touch the case.

The next witness relied upon by plaintiff is Benjamin Tut-ton. I quote again from page 19: “Benjamin Tutton (page 18) says: I stopped running the machine; it was not in fit condition to work at that time. I told Biale and Bradtz it was not safe, and that I would not bother with it. We called it the ‘ hospital machine.’ ” The learned counsel have not cited, what in my view is the strongest part of the testimony of this witness. I will supply the omission : Q. “Now just state why it was unsafe? A. Well, the machine would start of its own accord after it was stopped. When I was working it the belt was not properly fit up.” Just what the witness intended by the remark that “the belt was not properly fit up” does not clearly appear. His subsequent cross-examination throws some light upon it. I give a portion of it. “Q. Then five (machines) were run with straight belts and five with crossed belts? A. Yes sir. Q. Was there any liability to start without your starting them ? A. There was if the pulleys were too loose: sometimes if you would shove it off too quick it would twist, and if you did not watch it carefully it would fly right back on the fast pulley again. Q. If you didn’t push it over far enough and hold, it there for a little bit until the belt had adjusted itself on the pulley above, it was liable to fly over on the fast pulley and start the machine? A. YYjs sir, it would do that; some machines would do that. Q. Was there anymore liability for one machine to start than there was for another, if it was handled properly ? A. No sir: Q. In any one of those machines if they were handled with prudence there was no danger of any one meeting with an accident? A. No sir.”

There is not a word here to show that the machine was out of order. If it was handled with prudence there was no danger. If the belt was not properly thrown off and held off a sufficient time, it would fly back and start the machine. This appears to have been the case with all the machines, especially those run with cross-belts. If the belt had become too loose whose business was it to know that fact? All leather belts will stretch with use and the person operating the machine is of all others the one to know that fact and to remedy the defect or call upon his employers to do so.

The next witness was George Soupper. I quote again from page 19. “ George Soupper (page 16) says ifc would work sometimes, and sometimes it would not work; it was not as regular as the other machines; it was run by a crossed belt; if it was not handled with a good deal of care it would throw it in a twist, and if he would shove it over too quick it would fly back on the tight pulley again and start the machine.” The witness is not speaking of any defect in the machine or its construction. He is referring to the mode of handling it. This is clear from his cross-examination a small portion of which I give: Q. “ Then to give it a sudden jerlt in letting your lever go, of course the tendency of the belt would then be to go right back again? A. Yes, it would, if you would throw it over rapidly it would take it right over on the tight pulley again. Q. That is what caused the starting, is it not? A. Yes, sir. Q. Then it would not have started if it were properly adjusted? A. No, sir. Q. Then it was just like any other machine that was operated in that building in regard to starting and stopping? The belt had to be adjusted on the loose pulley before you would let go of your lever? A. Yes, sir.”

I quote again from the argument: “L. Ross, (page 19) says there was a wire attachment to tighten the lever, and in his opinion it was there to fasten the lever back so it would not start.” We are not informed by testimony or otherwise that this wire attachment was out of order or that it rendered the machine unsafe. So far as we can form an opinion it would seem to have been placed there from motives of safety. It has not been shown to have contributed to the accident.

I quote again from the argument: “ The plaintiff testifies that he was careful and had stopped the machine, and waited some time before he reached to remove the spool of barbed wire. The defendants alleged that the plaintiff put his foot upon the platform on which the machine stood. This the plaintiff denied and showed the jury in what manner he had placed his foot.”

The only portion of this paragraph that needs comment is that portion which refers to the plaintiff’s testimonjn He does state that he was careful and had stopped the machine. I have no doubt the plaintiff thought he was careful and had stopped the machine long enough for the belt to adjust itself. That he was mistaken is shown not by the result merely, but by the testimony of his own witnesses, which I have cited above.

This was all of the evidence relied upon by the plaintiff as entitling him to go to the jury, excepting the declarations of Riale, the superintendent, made after the accident. We are not disposed to rule this case upon them. His declarations were clearly incompetent to affect anyone but himself, and if objected to must have been ruled out. Besides, they are fairly offset by the plaintiff’s own declaration made at the same time that, “ Perhaps it was a little carelessness on my part.”

It is possible that a jury would find the negligence were the ease submitted to them. This is the greater reason why we should not direct the submission in the absence of sufficient evidence. The plaintiff has met with a serious calamity which enlists our warmest sympathies, but we would be doing a wrong were we to place the burden of making compensation for that calamity upon shoulders that are not entitled to bear it.

Judgment affirmed.